Electrical Panel Load Calculator

Electrical Panel Load Amps, Headroom & Generator for Your Home

Most homeowners have no idea how close their panel is to its limit. A full panel of breakers is often a half-empty panel of load. Our free calculator returns amps used, spare capacity, overload verdict, and a standby generator recommendation — based on NEC demand factors. Built by Shandong Huali, a diesel generator manufacturer since 1999, with models from 8–4,000 kVA. Get a factory-direct quote with your results pre-filled.

Check load in amps
Spare capacity & overload verdict
Generator sizing & EV fit
Check My Panel Load
Free tool – get your amps, headroom, and a backup quote.
Shandong Huali

Diesel Generator Manufacturer

Factory-direct home backup since 1999.

25+ Years experience
8–4,000 kVA generator range
20+ Countries supplied
Panel Load Basics

What an Electrical Panel Load Calculator Does

An electrical panel load calculator works out how much electrical demand your home or small business actually draws, in amps and watts, against the rating of your panel and service. It applies the demand factors of the National Electrical Code (NEC) to your lights, outlets, appliances, and HVAC, then returns the number every power decision hangs on.

Amps Current Load

What is my current panel load in amps? The calculator returns the real draw of your home against your panel rating.

Headroom Spare Capacity

How much spare capacity do I have left? The calculator shows your remaining amps against the 80% continuous limit.

Verdict Is My Panel Overloaded?

The calculator gives a clear verdict — overloaded, tight, or OK — so you know before you add a circuit or an EV charger.

Connected Load vs Demand Load

The difference between connected load and demand load is the whole game. Connected load is every watt of everything installed. Demand load is what the house actually draws at its peak, after demand factors, because nothing runs at full capacity at the same time. A 200 amp panel can legally hold 400 amps of breakers, and a home at 80 amps of real demand is nowhere near overloaded. Code-based demand factors turn the first number into the second, and that's the figure that sizes your service, your panel, and your backup generator.

Answers Five Key Questions

What the Calculator Tells You

01
Current Panel Load

What is my current panel load in amps? The calculator returns your exact draw in amps and watts against your panel rating.

02
Spare Capacity

How much spare capacity do I have left? The calculator shows your remaining amps and utilization percentage.

03
Overload Verdict

Is my panel overloaded? The calculator gives a clear verdict based on the 80% continuous load limit.

04
EV Charger Fit

Can I add a Level 2 EV charger or a new circuit? The calculator shows if your panel has room for the extra load.

Electrical Panel Load Calculator
Panel Load Tool

Electrical Panel Load Calculator

Enter your panel size, square footage, and appliances. The calculator applies NEC 220.82 demand factors and returns your load in amps, spare capacity, overload verdict, and EV charger fit.

Panel & Home Details

Fill in your panel size and home characteristics. Equipment defaults are pre-loaded for a typical residence.

Appliances & Loads (VA)

Edit values to match your home. Lighting and laundry are auto-calculated.

Continuous load: counted at 125%
Panel Capacity Chart

Electrical Panel Capacity Chart

The chart below is a planning reference for the common residential and light-commercial service sizes.

Panel / Service Theoretical Max 80% Continuous Limit Typical Home Usage
100 A 24,000 W 80 A (19,200 W) Older and smaller homes, often tight for all-electric
150 A 36,000 W 120 A (28,800 W) Mid-size homes with gas heat
200 A 48,000 W 160 A (38,400 W) Most homes use 80 to 90 A at peak
400 A 96,000 W 320 A (76,800 W) Large estates, shops, light commercial
The 80% planning rule is the column that matters. It exists because breakers, panels, and conductors are rated for a continuous load, and the code caps a continuous load at 80% of the rating so the gear runs cool and the breaker holds. A 200 amp panel gives you 160 amps of usable headroom, and most homes live well under that.

Electrical Panel Load Example

2,500 sq ft all-electric home with a 200 A panel, 5,000 VA heat pump, electric range and dryer.
Lighting: 2,500 × 3 = 7,500 VA. Laundry: 1,500 VA. Range + dryer: 6,000 VA.
Demand factor: first 10,000 VA at 100%, remainder at 40% = 10,000 + (5,000 × 0.4) = 12,000 VA.
HVAC: 5,000 VA. Total: 12,000 + 5,000 ≈ 17,000 VA ≈ 71 A at 240 V.
EV charger test: Add Level 2 (40 A, 9.6 kW, 125% continuous = 50 A). Home lands at 121 A, under the 160 A line. Fits — no panel upgrade needed.
That's the honest answer the calculator gives: a verdict on your panel today, and a second verdict the moment you add the next appliance.

Load Calculation Method

How to Calculate Electrical Panel Load

To calculate electrical panel load, total your lighting at 3 VA per square foot, add 1,500 VA for laundry and each appliance circuit, apply the demand factor, add the larger of your heating or cooling load, then divide the total VA by 240 volts to get amps. Compare the result against 80% of your panel rating.

STEP 01

List Your Loads

Lighting at 3 VA per square foot, 1,500 VA for the laundry circuit, and the nameplate load of each major appliance — range, dryer, dishwasher, water heater, and any other fixed equipment.

STEP 02

Apply the Demand Factor

The first 10,000 VA counts at 100%, and everything above it at 40%. This accounts for the fact that not all loads run at full capacity simultaneously in a typical home.

STEP 03

Add Heating or Cooling

Count only the larger of the two — heating or cooling — because they do not run together. Include the air conditioner compressor, heat pump, or electric furnace nameplate rating.

STEP 04

Convert VA to Amps

Divide the total volt-amps by your system voltage — 240 V for a typical home — to get the load in amps. This is the actual current draw your panel must support under normal conditions.

STEP 05

Compare Against the 80% Line

A continuous load may use only 80% of the panel rating. A 200 amp panel's practical ceiling is 160 amps. If your calculated load exceeds that, it's time to upgrade or redistribute.

Worked Example

2,000 sq ft Home — 82 A Calculated Load

Lighting: 2,000 × 3 = 6,000 VA. Laundry: 1,500 VA. Appliances (range, dryer, dishwasher): 14,200 VA. Subtotal: 21,700 VA. Demand: first 10,000 VA at 100% = 10,000 VA; remaining 11,700 VA at 40% = 4,680 VA. Subtotal: 14,680 VA. HVAC (5,000 VA, larger than heating): total 19,680 VA. 19,680 ÷ 240 = 82 A. A 200 A panel at 80% = 160 A capacity, so this panel has 78 A of spare capacity.

Warning Signs

Is My Panel Overloaded? Warning Signs

Most overloaded panels announce themselves before they fail. Our engineers and the electricians we work with see the same patterns — here are the six most common indicators that your panel may be near its limit.

01

Unexplained Breaker Trips

The main breaker, or a branch breaker, kicks off when two big loads run together. If this happens regularly with no clear cause, the panel is likely being pushed beyond its capacity.

02

Flickering or Dimming Lights

Lights that flicker or dim when the AC, the sump pump, or a space heater kicks on point to voltage sag under load — a classic sign of an overloaded or undersized service.

03

Warm Panel or Breaker Handles

Heat is the overload's calling card. A warm panel or warm breaker handles indicate excessive current flow, which also damages the breakers over time and creates a fire risk.

04

Nuisance Trips in Kitchen or Laundry

Frequent tripping in the kitchen or laundry, where loads stack up — toaster, microwave, dishwasher, dryer — suggests the branch circuit is overloaded and the panel may be nearing its limit.

05

No Room to Grow

The panel is full of breakers and you need one more circuit. A fully populated panel often means the service was sized for yesterday's loads, with no allowance for future additions.

06

Appliances That Sag at Full Power

When the service can't hold the voltage under load, appliances run sluggish — motors slow down, compressors strain, and performance drops. This is a strong indicator of an overloaded panel.

Common Errors

5 Electrical Panel Mistakes

Our engineers see these five errors more than any others on residential and small commercial jobs. Avoiding them saves money, prevents nuisance trips, and keeps your electrical system safe.

01

Adding Up Breaker Sizes

A 200 amp panel can hold 400 amps of breakers and be code-legal. Breakers protect wires; load diversity decides the real demand. Adding breaker ratings tells you nothing about actual load.

02

Ignoring the Demand Factor

Counting every connected watt with no diversity oversizes the service, the panel, and any generator you buy. The NEC demand factor exists because loads don't all run at once — use it.

03

Skipping the 80% Rule

Treating a 200 amp panel as 200 amps of usable load invites nuisance trips and an overheated panel. Continuous loads must not exceed 80% of the breaker or panel rating — 160 amps for a 200 A panel.

04

Forgetting Continuous Loads

EV chargers, well pumps, and sump pumps run for hours at a stretch. These continuous loads count at 125% of their nameplate rating when sizing the circuit and the panel.

05

Guessing Instead of Measuring

For an existing home, a utility smart-meter peak — run through NEC 220.87 — beats any estimate. A clamp meter on the service conductors gives you live amps, and the data is free from your utility.

If you see the warning signs, the real check is to measure, not guess. A clamp meter on the service conductors gives you the live amps, and your utility's smart-meter data — downloadable as a Green Button file — gives you the actual 12-month peak. The calculator runs the NEC 220.87 real-usage method on that number: your peak demand times 125%, plus any new load times 125%, must stay under the panel rating.

Let's talk

Get a Home Backup Assessment

Our engineers will review your panel load calculation, confirm your spare capacity, and deliver a factory-direct price — no obligation, no hidden fees. Every quote includes the generator, automatic transfer switch, and soundproofed enclosure for a complete home backup solution.

Frequently Ask Questions

Get in touch with us
Leave a message
Contact Form Demo